Extraction Canopies Cleaning - 01733 700468

Why it’s a good ideal to get your extraction canopy system cleaned

There are several reasons why you should have your extraction system cleaned, potential fireplace hazard, which can comply along with your insurance policy, helps with the performance of your system and to stop the build-from grease, mud and harmful bacterial. A fire waiting to happen Extraction system filter can never eliminate all vaporized grease that, together with debris, condenses onto the canopy plenum, duct and fan surfaces. This build-up now solely requires heat-readily offered in each kitchen to trigger off a frightening process. A spark or flame is not necessary, as spontaneous combustion will occur. The grease within the duct acts as a fuse, carrying fireplace through the duct and the building. Fireplace, smoke and hot gases might break out at any penetration, hole, joint or discharge point or following heat-induced collapse of ductwork Temperatures up to 1200 degC transmit heat through the metal to distort, destroy or ignite nearby cloth like duct support hanger, packing materials, electrical systems and litter. In this way hearth can spread rapidly following duct route that may be difficult and dangerous for hearth fighters to access. Insurance risk The insurance business is hardening its perspective on the issue. This is often hardly surprising since the association of British insurers has recorded losses associated with dirty kitchen extract fires rising from £sixty-five million in 1998 to £107 million in 2004. The insurer’s loss prevention council suggest that a minimum of annual cleaning of entire systems by specialists is carried out, the exact frequency to be determined by reasoned risk assessment. Failure to comply with the terms of a policy may mean invalidation of your policy. Often tiny print on insurance policy is over looked this is often where all the necessities are found. Thus please take the time to scan all the little print very carefully. Below are clauses taken from major insurers in the UK, detailing the clauses that must be coated by warranties to validate the cover. AXA Grease traps filters and other grease removal devices are cleaned every week. The grease extract ducting is cleaned each 6 months. Deep fat frying clause used on pubs, hotels etc All extraction hood canopies, filters and grease traps are cleaned at least once each seven days All extraction ducts are cleaned at least once every twelve months by a specialist contractor. Sterling Extraction hoods, canopies, fat/grease collectors and filters are cleaned a minimum of once each 7 days. Specialist ductwork cleaners NIG Extraction ducts are cleaned at least once each six months St Pauls Clause Deep fat frying The extraction ducts and flues are to be cleaned at least monthly If this condition is not complied with, this section will not cover fire or explosion harm caused by the deep fat frying apparatus at such business premises. Hazards of a unclean kitchen extraction system Even the most effective extraction filters will not remove all traces of grease and dirt from the air, over time a layer of grease and dirt is deposited on the surface of ventilation duct, canopies and extraction fans after time your extraction system can start to slow down and you will hear undue noise or vibration this is due to the grease and dust baking troublesome that then forms a carbon prefer deposit, this will cause overheating and fans to cut out and low airflow pressure. This excessive grease is also an environmental health hazard and creates a breeding ground for bacteria and foul odours. It is there for essential to carry out regular cleaning to your kitchen extraction system this should be carried out by a specialist contractor that will offer you with photos before and after and a sound certificate, failing to do thus could cause a breech of the Environmental Health Laws and might invalidate your hearth insurance policy. Cover UK Extraction Degreasing and Maintenance Service As a member of the heating and ventilation contractors association and the FSB, Canopy UK provides a ventilation degreasing service to the HVCA TR19 covering all aspects of extraction system cleaning. Our experienced cleaning team are fully trained to wash all components of ventilation systems to the high normal required to confirm a secure and healthy atmosphere for your workers and customers. Here at Cover UK we have a tendency to believe in customer care that is why we tend to provide not only a deep clean service, but after care service with one of our maintenance plans that begin from as very little as £24.fifty re month. As you are aware your extraction system never goes down on a Monday morning at nine o clock, it necessarily looks to happen on a Friday night or over the weekend, along with your Canopy UK maintenance service we tend to aim to possess you up and running within 24 hours this offers you peace of mind that you are in safe hands and knowledge that you have got saved yourself from lost revenue. This service includes cleaning of all accessible duct work, the fans, filters and canopy, pictures can be taken before and when and you may also receive a duplicate of the pictures along with a valid certificate for your insurance policy.